WHEELCARE SUPERLIGHT User Manual

SUPERLIGHT Scooter User’s Manual WHEELCARE, Inc. 12691 Monarch Street Garden Grove California 92841 Tel 800-448

7 2.2 Joining Tiller to Frame. (Cont.) d. Connect the Electric Plug to the Socket in the Tiller (See Fig. 4). Figure 4.

8 2.3 Installation of Batteries (See Fig. 5) Note: Installation of L.H Battery is identical to R.H. Battery. L.H. Battery is shown. a. Place batt

9 2.4 Installation of Batteries Cover (See Fig. 6) a. Place Batteries Cover over the Batteries b. Push back Plastic Clip to secure the Batteries Co

10 Figure 6.

11 2.5 Seat Installation (Figure 7) Seat Installation and Adjust: a. Insert the Seat Adapter into the Seat-Bushing. (1) Verify that the Seat-Bushi

12 Figure 7.

13 2.6 Rear Basket Installation a. Install the Rear Basket by placing it on Support Rod welded to the rear frame. (See Fig. 8). Figure 8.

14 2.4 After the assembly make sure that: - a. All parts are undamaged, properly assembled and secured. b. All electrical plugs are properly faste

15 2.5 Seating into the SUPERLIGHT a. For comfort entering into the SUPERLIGHT (See Figure 9). b. Lift the Seat Turning Lever and turn the Seat 45

16 Figure 9.

WARNING Read carefully before assembly, disassembly and operating the SUPERLIGHT. If you do not fully understand any part of this Manual, please co

17 CHAPTER 3 - OPERATING INSTRUCTIONS PLEASE READ THOROUGHLY CHAPTER 8 - “SAFETY INSTRUCTIONS” - BEFORE DRIVING THE SUPERLIGHT. 3.1 Mount the SUPER

18 Figure 10.

19 3.4 The SUPERLIGHT has 2 speed modes ; Low / High a. In the High speed mode (marked by the “hare” symbol next to the Speed Selector switch) the

20 Figure 11.

21 3.7 Lights Operating (See Fig. 12) To switch on the SUPERLIGHT light, use the Right-Blue switch . . 3.8 Battery Capacity Indicator (See Fig. 12)

22 Figure 12. Charging fuse

23 3.9 In case of power fail, low battery or other fail The SUPERLIGHT can be pushed manually by turning the Motor Cap Knob in clockwise (See Fig.

24 Figure 13.

25 CHAPTER 4 - DISASSEMBLY 4.1 Separation of Tiller from Frame (See Fig. 14). For ease of operation we recommend working on the left side of the

26 Figure 14.

A CONTENTS Subject Page CHAPTER 1 - DELIVERY and UNPACKING ... 1 CHAPTER 2 - ASSEMBLY...

27 4.2 Removal of Seat (See Fig. 15) a. Remove the Seat from the Seat Adapter by lifting the Seat straight up while turning Release Lever is pull

28 Figure 15.

29 4.3 Removal of Batteries Batteries can be easily removed from your SUPERLIGHT as follows - a. Remove Seat and Rear Basket (see instructions in p

30 d. Remove each battery BY PULLING UP THE HANDLE AND LIFTING THE BATTERY (See Fig. 17). WARNING Failure to follow above instructions could cau

31 4.4 Removal and Installation of Rear Wheel/s (See Fig. 18) Rear Wheel/s can be removed to facilitate storage at home, in the trunk of your car o

32 Figure 18.

33 CHAPTER 5 - CHARGING BATTERIES The Battery Charger supplied with your SUPERLIGHT controls the charging operation, prevents over-charging and prol

34 Figure 19.

35 When charging is complete and you are ready to go - unplug the Charger from the wall outlet and then pull out the charging plug from the charging

36 5.2 Charging Adapter (Optional) The Charging Adapter enables charging the batteries when they are removed from the SUPERLIGHT. This is needed whe

1 CHAPTER 1 - DELIVERY and UNPACKING The SUPERLIGHT Scooter is delivered to you packed in 2 Cardboard Boxes. . Note: The boxes weights 30+28kg (6

37 CHAPTER 6 - STORING IN CAR See Fig. 20 The SUPERLIGHT design, its small dimensions and low weight allow for easy and simple storage and trans

38 Figure 20.

39 CHAPTER 7 - TROUBLESHOOTING No. Trouble Probable Cause Corrective Action 1 Green Lamp not ON when Key is turned, Or the Green lamp is

40 CHAPTER 7 - TROUBLESHOOTING (Cont.) No. Trouble Probable Cause Corrective Action 5 Drive is not smooth or drive is irregular. - Batteries no

41 BATTERY CHARGER - TROUBLESHOOTING No. Trouble Probable Cause Corrective Action 1 Charger indicator is not ON while the charger is plugged in

42 CHAPTER 8 - SAFETY INSTRUCTIONS The SUPERLIGHT can be operated indoors, as well as outdoors on flat paved surfaces. Please note and strictly a

43 8.7 The SUPERLIGHT is designed and built to be carry ONE person only: Never operate it with an additional person or child on board. 8.8 CLEANING :

44 CHAPTER 9 - SERVICE Your SUPERLIGHT is designed and built to provide a long, useful and troublefree life. Occasionally it may require service d

45 Periodical servicing requirements No. Service Frequency 1 Check tires for damage and replace if necessary. Every two Month 2* General check of

46 c. The air pressure of the tires should be inspected every two weeks, especially after a long storage time period. d. Normal tire air

2 Figure 1.

47 CHAPTER 10 - SPECIFICATIONS * DIMENSIONS: Metric (cm) U.S. (inches) Width 62 24.4 Length with straight handlebars 115 45.3 Height of seat fr

48 (Cont.) Maximum allowed side angle 13 % 7.4 deg. WHEELS & MARKINGS ON TIRES: Front - Solid, φ250 mm x 50 mm Rear - Solid, φ250mm x 50mm

49 CHAPTER 11 - EMI WARNING All types of electrically powered vehicles, such as powered wheelchairs and motorized scooters (in this text all types

50 2) Medium range mobile transceivers Such as those used in police cars, fire trucks, ambulances and taxis. These usually have the antenna mounted

51 personal communication devices such as cellular phones, while the powered vehicle is turned ON ; 2) Be aware of nearby transmitters, such as radi

52 AFIKIM ELECTRIC VEHICLES KIBBUTZ AFIKIM 15148, ISRAEL TEL: 972-4-6754814,

3 CHAPTER 2 - ASSEMBLY 2.1 Installation of Rear Wheels (See Fig. 2) a. Squeeze the center Pin in the Hub Cap. Push the wheel back on, to the e

4 Figure 2.

5 2.2 Joining Tiller to Frame. a. Place Tiller in front of the Frame. (See Fig. 3). Kneel at the left side of the SUPERLIGHT holding the left side o

6 Figure 3.